How To Change Thermostat On Jeep Cherokee 4 0 Inline Six Youtube This video is one of the easiest repairs on a jeep, if your heater is not hot or your jeep is overheating, you may want to replace your thermostat. New thermostat (stant 45358)gasket (fel pro 35630).
How To Replace The Thermostat On A 4 0l Jeep Handymanpf i replace a thermostat in detail on this 97 jeep cherokee. these 4.0l engines are common in alot of the jeeps for many years. thanks for wa. The hoses might be pretty stuck onto the thermostat so be prepared for a fight. 2. carefully disconnect the coolant temperature sensor and set the wiring out of the way. 3. remove the two, 1 2 inch bolts holding the thermostat housing on. the top one is much longer than the bottom one. the serpentine belt might be in the way of the lower bolt. First, marginal cooling system to start with. second, the temp sensor for the gauge is at the back of the engine in the head, the hottest place in the engine cooling system. it might be 220° there, but only 195 at the stat. it is a problem with a long engine block with the coolant coming all the way from the front. 8. fill the radiator with coolant. 9. reconnect the negative battery cable. 10. start the engine and check for leaks. most cars can be repaired without much experience by simply replacing the thermostat. in the jeep cherokee, the thermometer rests at the top of the motor, making it even easier to use. fill a two gallon bucket halfway with water.
Jeep Cherokee Thermostat Replacement Procedure 84 01 Xj Mj Yj Tj First, marginal cooling system to start with. second, the temp sensor for the gauge is at the back of the engine in the head, the hottest place in the engine cooling system. it might be 220° there, but only 195 at the stat. it is a problem with a long engine block with the coolant coming all the way from the front. 8. fill the radiator with coolant. 9. reconnect the negative battery cable. 10. start the engine and check for leaks. most cars can be repaired without much experience by simply replacing the thermostat. in the jeep cherokee, the thermometer rests at the top of the motor, making it even easier to use. fill a two gallon bucket halfway with water. Step 2 – remove the thermostat. locate the upper radiator hose. it goes from the top of the radiator to the thermostat assembly. remove the clamp on the edge of the hose on the thermostat side. remove the hose by pulling it out. keep a rag underneath it to avoid any small spills. You have a operating range. the hysteresis causes the temp to continue in a direction and overshoot. that means that when the tstat opens at 195 out will continue to heat until 200 and when it cools it will drop below 190. that is why the tstat is at 195. it keeps the operating range above the closed loop set point.
How To Replace The Thermostat On A 4 0l Jeep Cherokee Dust Runners Step 2 – remove the thermostat. locate the upper radiator hose. it goes from the top of the radiator to the thermostat assembly. remove the clamp on the edge of the hose on the thermostat side. remove the hose by pulling it out. keep a rag underneath it to avoid any small spills. You have a operating range. the hysteresis causes the temp to continue in a direction and overshoot. that means that when the tstat opens at 195 out will continue to heat until 200 and when it cools it will drop below 190. that is why the tstat is at 195. it keeps the operating range above the closed loop set point.
How To Replace The Thermostat On A 4 0l Jeep
Comments are closed.